MINI PLANT SISTEM PENGENDALI BERAT LIMESTONE PADA PLTU TANJUNG JATI B UNIT #3&4 BERBASIS PLC DAN ARDUINO MEGA 2560
DOI:
https://doi.org/10.26905/jasiek.v1i1.3144Abstract
PLTU Tanjung Jati B Unit #3&4 merupakan unit pembangkit yang menghasilkan produksi listrik sebesar 660 MW setiap hari nya. Bahan bakar yang digunakan batu bara yang menghasilkan produk utama yaitu Flue Gas dan Ash yang mempunyai limbah industri B3 yang penanganannya membutuhkan metode khusus menggunakan FGD (Flue Gas Desulfurization) yaitu alat yang berguna untuk mereduksi Sulfur Dioksida (SO2) dari Flue Gas hasil pembakaran PLTU. Pada proses FGD, batu kapur (limestone) digunakan sebagai bahan injeksi FGD, berfungsi mengikat SOx menjadi gypsum sehingga kadar emisi SOx dari hasil pembakaran batu bara aman bagi lingkungan. Perancangan Mini Plant Sistem Pengendali Berat Limestone pada FGD berbasis PLC dan Arduino Mega 2560 sangat diperlukan untuk menjaga perhitungan stock Limestone yang akurat secara otomatis agar emisi SOx dapat tereduksi dengan baik.
Â
References
J. A. de L. Perini et al., “Optimisation of the removal conditions for heavy metals from water: A comparison between steel furnace slag and CeO2nanoparticles,†Arab. J. Chem., 2017.
I. Hrastel, M. Gerbec, and A. Stergaršek, “Technology optimization of wet flue gas desulfurization process,†Chem. Eng. Technol., 2007.
R. Jamil, L. Ming, I. Jamil, and R. Jamil, “Application and Development Trend of Flue Gas Desulfurization (FGD) Process: A Review,†Int. J. Innov. Appl. Stud. ISSN, 2013.
Handy Wicaksono and Josaphat Pramudijanto, “Kontrol PID Untuk Pengaturan Kecepatan Motor DC Dengan Metode Tuning Direct Synthesis,†J. Tek. Elektro, 2004.
I. Mujahidin, R. Yuwono, and A. Mustofa, “Rancang Bangun Rectifier Antenna Mikrostrip Ufo Pada Frekuensi Ultra Wideband (UWB) Sebagai Pemanen Energi Elektromagnetik,†J. Mhs. TEUB, vol. 3, no. 2, 2015.
W. Bolton, “PLC systems,†in Instrumentation and Control Systems, 2007.
X. Zhang, X. Li, and K. Lu, “Research on an intelligent solar tracking system based on LPC2131,†in Proceedings - 2012 3rd IEEE International Conference on Network Infrastructure and Digital Content, IC-NIDC 2012, 2012.
M. A. R. Arif Rahman Hakim, Sumardi, “Kontrol Posisi Pada Sistem Pergerakan Mobile Robot Kinematic,†Article, 2015.
I. Mujahidin, “Directional 1900 Mhz Square Patch Ring Slot Microstrip Antenna For WCDMA,†JEEMECS (Journal Electr. Eng. Mechatron. Comput. Sci., 2019.
G. P. H. Sandaruwan, P. S. Ranaweera, and V. A. Oleshchuk, “PLC security and critical infrastructure protection,†in 2013 IEEE 8th International Conference on Industrial and Information Systems, ICIIS 2013 - Conference Proceedings, 2013.
Mujahidin, I., Pramono, S. H., & Muslim, A. (2018, October). 5.5 Ghz Directional Antenna with 90 Degree Phase Difference Output. In 2018 Electrical Power, Electronics, Communications, Controls and Informatics Seminar (EECCIS) (pp. 224-228). IEEE.
L. E. Kallinikos, E. I. Farsari, D. N. Spartinos, and N. G. Papayannakos, “Simulation of the operation of an industrial wet flue gas desulfurization system,†Fuel Process. Technol., 2010.
F. M. W. Fatih Mutamimul Wildan, “Sistem Pengaturan Kecepatan Motor Induksi Tiga Fasa Menggunakan Kontroler PID Berbasis Genetic Algorithm,†KINETIK, 2016.
J. T. Elektro, F. T. Industri, and U. K. Petra, “Kontrol PID Untuk Pengaturan Kecepatan Motor DC Dengan Metode Tuning Direct Synthesis,†vol. 4, no. 1, pp. 10–17, 2004.
L. P. Ketaren, M. Ma, and M. Rahmawaty, “Balancing Robot Beroda Dua Menggunakan Metoda Kontrol Proporsional , Integral dan Derivatif,†J. Elem., 2015.
Downloads
Published
Issue
Section
License
Authors who publish with this journal agree to the following terms:
The journal allow the authors to hold the copyright without restrictions and allow the authors to retain publishing rights without restrictions.
Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution-ShareAlike 4.0 International License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
